Indiana Truck Weight and Size Limits
Legal limits for a truck in Indiana without a permit: Interstate axle and gross weights, height, width, and semitrailer length, each with its official source.
Data pending verification
Some official figures this page relies on haven't been confirmed against the source yet. Don't rely on results here until this notice is gone.
What's pending
- weight-limits/states/indiana
Indiana limits at a glance
| Limit | Indiana | Source |
|---|---|---|
| Interstate gross weight | 80,000 lb | 23 CFR 658.17, Weight (eCFR) |
| Interstate single axle | 20,000 lb | 23 CFR 658.17, Weight (eCFR) |
| Interstate tandem axle | 34,000 lb | 23 CFR 658.17, Weight (eCFR) |
| Width (National Network) | 102 in | 23 CFR 658.15, Width (eCFR) |
| Height | Pending verification | FHWA, Compilation of Existing State Truck Size and Weight Limit Laws (Report to Congress, May 2015), Appendix A: Indiana |
| Semitrailer length | Pending verification | FHWA, Compilation of Existing State Truck Size and Weight Limit Laws (Report to Congress, May 2015), Appendix A: Indiana |
| Grandfathered semitrailer length | 48 ft 6 in | 23 CFR part 658, Appendix B, Grandfathered Semitrailer Lengths (eCFR) |
Interstate weight limits
Federal law sets the Interstate limits at 20,000 lb on a single axle, 34,000 lb on a tandem, and 80,000 lb gross, with the bridge formula on every axle group (23 CFR 658.17). States may keep higher limits they had before the federal limits took effect ("grandfather rights").
Grandfathered: up to 127,400 lb GVW, 22,400 lb single, and 36,000 lb tandem on the Indiana Toll Road (I-80/90).
FHWA on Indiana: Indiana has a grandfather provision under Federal law (23 CFR Part 658, Appendix C) to allow vehicles to operate up to 22,400 lbs. on a single axle, 36,000 lbs. on a tandem axle, and 127,400 lbs. GVW on parts of the Interstate system (Indiana Toll Roads). See the Routes section for a full description of the routes to which this grandfather provision applies.
Bridge formula check with Indiana limits
A 5-axle tractor-trailer is filled in. Change the spacings and weights to match your rig; the limits for single axles, tandems, and gross are Indiana's Interstate limits.
Your result
Indiana limits off the Interstate
FHWA's summary of Indiana law for trucks in regular operation (no permit), including non-Interstate highways. It reflects state law as of October 1, 2012; check the state for later changes.
- Single axle
- State and Interstate highways: 20,000 lbs. / Heavy duty highways: 22,400 lbs. / Extra heavy duty highways: 18,000 lbs.
- Tandem axle
- State and Interstate highways: 34,000 lbs. / Heavy duty highways: 36,000 lbs. (18,000 lbs. for each axle) / Extra heavy duty highways: 32,000 lbs.
- Tridem axle
- 50,000 lbs. with lift axle, 48,000 lbs. otherwise
- Gross weight
- State and Interstate highways: 80,000 lbs. / Heavy duty highways: 80,000 lbs. (90,000 lbs. on the Indiana Toll Road) / Extra heavy duty highways: 134,000 lbs.
- Other
- 800 lbs. per inch width of tire; 1.5 percent scale tolerance
Where Indiana allows more than federal limits
- Indiana State statute allows for several axle and GVW exemptions for various types of vehicles and commodities.
- Indiana State statute allows for two types of weight tolerances for axle and/or GVW.
Height, width, and length
- Width: 102 inches. States may not set a width limit of more or less than 102 inches on the National Network (23 CFR 658.15(a)). Permits can allow wider loads.
- Height: pending verification. There is no federal height limit; each state sets its own.
- Semitrailer length: pending verification.
- Grandfathered semitrailer length: 48 ft 6 in. The minimum semitrailer length the state must allow in a tractor-semitrailer combination on the National Network, based on lengths legal in the state on December 1, 1982. Federal law also requires at least 48 ft (23 CFR 658.13(b)(1)). Semitrailers up to 53 ft may operate without a permit with a kingpin-to-rearmost-axle distance of 40 ft 6 in.
Over these limits you need a permit. Indiana oversize/overweight permits (317-615-7200).
Indiana compared with neighboring states
| State | Gross | Single | Tandem | Height | Semitrailer |
|---|---|---|---|---|---|
| Indiana | 80,000 lb | 20,000 lb | 34,000 lb | Pending | Pending |
| Illinois | 80,000 lb | 20,000 lb | 34,000 lb | Pending | Pending |
| Kentucky | 80,000 lb | 20,000 lb | 34,000 lb | 13 ft 6 in on highways the Transportat… | 53 ft on designated highways |
| Michigan | 80,000 lb | 20,000 lb | 34,000 lb | 13 ft 6 in | 50 ft |
| Ohio | 80,000 lb | 20,000 lb | 34,000 lb | 13 ft 6 in | 53 ft in a tractor-semitrailer combina… |
Sources
Source: 23 CFR 658.17, Weight (eCFR) · Last verified Sep 28, 2026
Source: FHWA, Compilation of Existing State Truck Size and Weight Limit Laws (Report to Congress, May 2015), Appendix A: Indiana · Effective Oct 1, 2012 · Last verified Sep 28, 2026
Source: FHWA, Compilation of Existing State Truck Size and Weight Limit Laws (Report to Congress, May 2015), Appendix B: Summary of State Exceptions to Federal Truck Weight Limits · Effective Oct 1, 2012 · Last verified Sep 28, 2026
Source: 23 CFR 658.15, Width (eCFR) · Last verified Sep 28, 2026
Source: 23 CFR part 658, Appendix B, Grandfathered Semitrailer Lengths (eCFR) · Last verified Sep 28, 2026
Source: FHWA, Oversize/Overweight Load Permits: State permit contacts · Last verified Sep 28, 2026
Limits change, and cities, counties, and posted bridges can set lower ones. Check with Indiana before you run a load near the limits. Page data last verified Sep 28, 2026.